Search found 144 matches

by Rigger
Sun Feb 25, 2018 5:39 pm
Forum: The Workshop
Topic: CV Joint rubbers replacement
Replies: 6
Views: 77

Re: CV Joint rubbers replacement

pietpetoors wrote:
Sun Feb 25, 2018 12:22 pm
Saw a photo of a Prado the other day where the lower ball joint fell out
That is a common Prado 90 problem (presume it is Prado 90), even happens with worn out OEM ball joints
Yes, it was indeed a 90 but the guy replaced ball joints 3 months prior to the incident with pirate parts.
by Rigger
Sat Feb 24, 2018 3:28 pm
Forum: The Workshop
Topic: CV Joint rubbers replacement
Replies: 6
Views: 77

Re: CV Joint rubbers replacement

If you do replace ball joints, please replace with OEM parts. Its going to be more expensive but pirate part cannot be trusted especially with suspensions. Saw a photo of a Prado the other day where the lower ball joint fell out while driving due to cheap parts used.
by Rigger
Fri Feb 23, 2018 4:45 pm
Forum: The Workshop
Topic: CV Joint rubbers replacement
Replies: 6
Views: 77

Re: CV Joint rubbers replacement

You should not assume anything. Jack it up and check the upper and lower ball joints with a tyre lever for play. There should be none. You can also check the control arm bushes. If all are good then just replace the CV boot rubbers.
by Rigger
Fri Feb 16, 2018 1:57 pm
Forum: 1979 to early 1998 Hilux (Gen 3&4 aka SFA 4x4)
Topic: 3.0 D4D engine into SFA
Replies: 15
Views: 551

Re: 3.0 D4D engine into SFA

Ja jy is reg. Die output shafts verskil omdat die transfer boxes verskil.
by Rigger
Fri Feb 16, 2018 8:44 am
Forum: The Workshop
Topic: Coolant Replacement
Replies: 13
Views: 379

Re: Coolant Replacement

Mars wrote:
Fri Feb 16, 2018 6:21 am
At most I would flush the radiator with clean fresh water.
I see Tim stays in Cape Town, better do that flush at midnight or someone might shoot you if you use drinkable water to flush a radiator :D:
by Rigger
Tue Feb 13, 2018 6:30 pm
Forum: The Workshop
Topic: D4D Diesel Smell
Replies: 5
Views: 141

Re: D4D Diesel Smell

If possible clean it with petrol and blow it dry with compressed air. Then check for leaks at the nuts on the fuel rail and injectors. The injector pipes sometimes crack just in top of the farrel where it seals. Secondly if all that is fine, spray some soapy water on the injector and look for bubble...
by Rigger
Tue Feb 06, 2018 10:10 pm
Forum: 1979 to early 1998 Hilux (Gen 3&4 aka SFA 4x4)
Topic: 3.0 D4D engine into SFA
Replies: 15
Views: 551

Re: 3.0 D4D engine into SFA

Die ratkas in die 1HZ Cruisers is presies dieselfde as die in die 4x4 D4d’s. Dis die R151f box. Dis net die transfer box wat verskil.
by Rigger
Mon Feb 05, 2018 10:25 am
Forum: The Workshop
Topic: Adjustable side mirror
Replies: 4
Views: 181

Re: Adjustable side mirror

Mine does the same. However if I hold it in for about 5 seconds or so then it starts to move. Both my mirrors does it. I have removed the switch and cleaned the connections. But didn’t change anything. I just live with it as I am driving the bakkie 99% of the time so no adjusting necessary.
by Rigger
Thu Feb 01, 2018 8:59 pm
Forum: Spares
Topic: KZTE Cylinder head
Replies: 5
Views: 211

Re: KZTE Cylinder head

There were still KZTE engines in the 120 Prado’s till 2008 or 2009 I think but looking at Opsmedics’s profile I think he meant 2001 and not 2011. I heard the AMC (I think thats the brand) is a better head than the original Toyota heads.
by Rigger
Sun Jan 28, 2018 8:08 am
Forum: Open Discussion
Topic: Toyota recall on air bags
Replies: 4
Views: 276

Re: Toyota recall on air bags

Replaced mine about two weeks ago at Toyota Stellenbosch. 20 min job. But the agents are battling with stock. Some agents have waiting list. Better make that appointment sooner than later.
by Rigger
Thu Jan 25, 2018 9:02 pm
Forum: General Hilux Discussions
Topic: Gearbox Problems Please Help
Replies: 6
Views: 231

Re: Gearbox Problems Please Help

Is your Hilux 4x4 or not? If yes, then you have a R151f gearbox which is famous for having weak 5th gears. Especially in the Land Cruiser pick ups with the same boxes, the guys struggle to get 150k km out of a box before the output shaft brakes the housing where the 5th gear bearing runs. That mecha...
by Rigger
Mon Jan 08, 2018 9:37 am
Forum: The Workshop
Topic: Tail lights, for fog and dash lights not working
Replies: 4
Views: 171

Re: Tail lights, for fog and dash lights not working

Did you tow a trailer? Look at the fuse box left of the steering collomb.
by Rigger
Mon Dec 25, 2017 8:55 am
Forum: The Workshop
Topic: Vigo 4L V6 Rev Counter
Replies: 1
Views: 198

Re: Vigo 4L V6 Rev Counter

Check all the connections on the alternator. Remove plug, clean and plug it back in. Could also be a connection on the back of the cluster.
by Rigger
Thu Dec 07, 2017 9:18 am
Forum: General Hilux Discussions
Topic: The fuel consumption of my Hilux
Replies: 326
Views: 92048

Re: The fuel consumption of my Hilux

Vehicle: 2011 3.0 D4D S/C 4x4 Km's on the clock: 152000km Motor: 1KD 3.0 Vehicle lift/ suspension: Standard Tyres: 31/10.5/R15 Carb mod/ spacers?: No Air filter: Standard Snorkel?: Yes EFI?: Std Cam cut?: No Exhaust mod: No Tyre pressure: 2.2 Bar Permanent roofrack/tent etc?: Cattle rails Aircon?: 8...
by Rigger
Wed Dec 06, 2017 8:36 pm
Forum: Late 2005 - 2016 Hilux (Gen 6 aka Vigo-shape)
Topic: Raad oor OME coils
Replies: 5
Views: 179

Re: Raad oor OME coils

Baie dankie vir al die info. Ek was nie seker oor die lengte van die coil nie. Alles maak sin wat jy sê. Ek gaan dan hulle nogsteeds koop en hou tot ek shocks kan koop.
by Rigger
Wed Dec 06, 2017 6:24 pm
Forum: Late 2005 - 2016 Hilux (Gen 6 aka Vigo-shape)
Topic: Raad oor OME coils
Replies: 5
Views: 179

Re: Raad oor OME coils

Ek het standaard Toyota shocks in. Het ‘n 40mm pyp bull bar wat seker so in die omgewing van 30-40kg weeg.

Gaan die coils nie met die gewone lengte shocks werk nie?

‘n Nuwe stel 883 coils is R4100 by 4x4Mega.
by Rigger
Wed Dec 06, 2017 12:14 pm
Forum: Late 2005 - 2016 Hilux (Gen 6 aka Vigo-shape)
Topic: Raad oor OME coils
Replies: 5
Views: 179

Raad oor OME coils

I have searched but can’t find anything that answers my questions. I can buy Old Man Emu front coils for my 2011 Vigo for R1600. It has done 20k km. Its the 2883 coils. My questions are: 1) Will it make any improvement to handling on and off road with the standard Toyota shocks? 2) I have a 30mm bod...
by Rigger
Sat Dec 02, 2017 3:54 pm
Forum: Wheels and Tyres
Topic: Advice please - Goodyear AT adv
Replies: 9
Views: 451

Re: Advice please - Goodyear AT adv

I also asked the same question a year or so ago on the forum regarding tires. And a lot of guys said General Grabbers was an excellent A/T tire for the price sensitive. Around R2k a tire. Haven’t tried it myself yet, but my dad has them on his Legend 45 and drive a lot of bad gravel roads and he is ...
by Rigger
Thu Nov 16, 2017 5:45 am
Forum: Open Discussion
Topic: RWC 2023
Replies: 3
Views: 292

Re: RWC 2023

Gelukkig kan nie een van hierdie ‘fat cats’ nou geld steel nie. Ek hou van al hierdie slegte goed wat met SA Rugby gebeur agv onder andere ons belaglike misdaad en moord syfers. Iewers moet iemand seker dan nou wakker skrik en besef die koffie is koud.
by Rigger
Thu Sep 21, 2017 1:39 pm
Forum: Wanted
Topic: HILUX Tailgate
Replies: 1
Views: 416

Re: HILUX Tailgate

Try scrap yards or Gumtree. I see a lot of load bins for sale on Gumtree
by Rigger
Sun Sep 17, 2017 8:53 am
Forum: The Workshop
Topic: 3L d4d 2012 clicking noise no power
Replies: 3
Views: 284

Re: 3L d4d 2012 clicking noise no power

The VNT or VGT stands for veriable nozzle turbine or veriable geometry turbine. Inside the turbo is vanes which changes its position so that you have optimal boost at all rev ranges.
by Rigger
Wed Jun 14, 2017 9:59 pm
Forum: The Workshop
Topic: Hulix vigo tie rod end
Replies: 4
Views: 438

Re: Hulix vigo tie rod end

The inner part that the tie rod screws into is called the rack end. The rack end srews into the steering rack shaft.
by Rigger
Sat May 20, 2017 5:41 am
Forum: The Workshop
Topic: Power loss now its dead
Replies: 5
Views: 601

Re: Power loss now its dead

Sounds like your alternator gave in. Start it with jumpers from another battery and then check charging with a multi meter. Should be between 14 and 14.5 volts
by Rigger
Mon May 15, 2017 1:12 pm
Forum: Meet the People
Topic: hilux 2l gearbox oil
Replies: 6
Views: 448

Re: hilux 2l gearbox oil

No it won't matter. The older gearboxes like yours ussualy runs on 80W90 but I don't think you will have a problem with 75W90
by Rigger
Mon May 15, 2017 12:40 am
Forum: Meet the People
Topic: hilux 2l gearbox oil
Replies: 6
Views: 448

Re: hilux 2l gearbox oil

I won't fill a gearbox with GL5. I believe there is a compound in that could harm the brass of the syncros over time. A EP90 or 80W90 GL4 will do the job
by Rigger
Sun May 14, 2017 11:14 pm
Forum: Meet the People
Topic: hilux 2l gearbox oil
Replies: 6
Views: 448

Re: hilux 2l gearbox oil

GL4 is for gearbox and transfer and GL5 for diffs
by Rigger
Tue May 09, 2017 3:36 am
Forum: Open Discussion
Topic: Anyone replaced Toyota Tazz tie-rods and tie-rod ends ?
Replies: 4
Views: 692

Re: Anyone replaced Toyota Tazz tie-rods and tie-rod ends ?

If you are mechanically challenged then better take it to a mechanic. Otherwise, no special tool required. Good old pipe wrench (bobbejaanspanner) and you are good to go. Thery are usually very tight and you should tighten them again very tight with some thread locker. And then mark the old tie rod ...
by Rigger
Thu May 04, 2017 1:38 am
Forum: The Workshop
Topic: D4D running rich.
Replies: 21
Views: 1197

Re: D4D running rich.

lukestoyzx wrote:
Wed May 03, 2017 10:50 pm
Did they your air flow meter when it was serviced? Should be done every time the air filter is changed.

Sent from my SM-N920I using Tapatalk
I think he meant to say did they clean it
by Rigger
Wed Apr 26, 2017 2:20 am
Forum: General Hilux Discussions
Topic: Radio Vervang Hilux D4D 2009
Replies: 14
Views: 856

Re: Radio Vervang Hilux D4D 2009

Ek bly in Oudtshoorn en het die radio by Oudtshoorn Toyota gekoop
by Rigger
Tue Apr 25, 2017 12:48 am
Forum: General Hilux Discussions
Topic: Radio Vervang Hilux D4D 2009
Replies: 14
Views: 856

Re: Radio Vervang Hilux D4D 2009

Ek het vir my Hilux, 2011 model pre-facelift so het die selfde dash in as joune by Toyota 'n radio gekoop wat staight fit is. Hy het aux en usb. Nie bluetooth nie maar was dadelik 'n groot upgrade van die een wat hy uit gekom het. En hy was maar R1000 direk by handelaars
by Rigger
Mon Apr 10, 2017 12:32 am
Forum: General Hilux Discussions
Topic: Xtra cab 4x4 GD 6 prys
Replies: 7
Views: 594

Re: Xtra cab 4x4 GD 6 prys

R458000 + R3500 on the road. So twee weke gelede by Toyota Paarl. Dink dis 'n baie goeie prys
by Rigger
Sun Mar 26, 2017 11:36 am
Forum: Accessories for Sale
Topic: High Lift Jack
Replies: 5
Views: 943

Re: High Lift Jack

Measure it. Its usually 48" or the bigger ones are 60" i think
by Rigger
Wed Feb 22, 2017 5:33 pm
Forum: General Hilux Discussions
Topic: TIME TO REPLACE MY TIRES, HOW GOOD IS THE BFG AT?
Replies: 9
Views: 669

Re: TIME TO REPLACE MY TIRES, HOW GOOD IS THE BFG AT?

I have KO2's on my Vigo and drive very bad gravel roads everyday. 10 000km and very happy with them
by Rigger
Tue Feb 21, 2017 5:27 pm
Forum: The Workshop
Topic: 4x4 gear leaver vibration.
Replies: 3
Views: 321

Re: 4x4 gear leaver vibration.

Hoe lyk die ratkas en transfer case mountings? Dis waar ek sal begin
by Rigger
Fri Feb 10, 2017 7:48 am
Forum: Meet the People
Topic: New Member - Problem already with Hilux :)
Replies: 7
Views: 565

Re: New Member - Problem already with Hilux :)

I agree with Knuppel, I have one myself that I service and it is a difficult diff to check oil not even mentioning replacing so i can just imagine how many guys skip it.

Try scrap yards around Joburg
by Rigger
Wed Feb 08, 2017 10:40 am
Forum: Meet the People
Topic: New Member - Problem already with Hilux :)
Replies: 7
Views: 565

Re: New Member - Problem already with Hilux :)

Elaborate a bit more on what exactly is worn. and yes the diff can be overhauled, you don't have to replace the complete diff
by Rigger
Wed Feb 08, 2017 8:02 am
Forum: General Hilux Discussions
Topic: tdi engines?
Replies: 5
Views: 374

Re: tdi engines?

This link explains all the engine codes and characteristics well

https://en.m.wikipedia.org/wiki/List_of_Toyota_engines
by Rigger
Wed Feb 08, 2017 7:57 am
Forum: Wanted
Topic: Wanted: 2006 Vigo centre console panel
Replies: 23
Views: 1949

Re: Wanted: 2006 Vigo centre console panel

Did you concider the Parrot?
by Rigger
Tue Feb 07, 2017 9:10 pm
Forum: Wanted
Topic: Wanted: 2006 Vigo centre console panel
Replies: 23
Views: 1949

Re: Wanted: 2006 Vigo centre console panel

I bought a radio from Toyota end of 2015 for my 2011 Vigo, same dash as yours for R1000 with aux and usb. And its a straight fit
by Rigger
Tue Feb 07, 2017 6:08 pm
Forum: General Hilux Discussions
Topic: tdi engines?
Replies: 5
Views: 374

Re: tdi engines?

The i in tdi stands for intercooler and has nothing to do with common rail or mechanical injection.

Toyota uses the letter E to indicate electronically controlled injection ie: 1KZ-TE shows it is the 1KZ series engine with a turbo and electronically controlled injector pump
by Rigger
Fri Jan 27, 2017 8:54 pm
Forum: Late 2005 - 2016 Hilux (Gen 6 aka Vigo-shape)
Topic: Central locking issue
Replies: 9
Views: 547

Re: Central locking issue

Try to get one at a scrap yard
by Rigger
Tue Jan 24, 2017 12:00 pm
Forum: The Workshop
Topic: 3.0 D4D stabilizer link gebuig
Replies: 4
Views: 292

Re: 3.0 D4D stabilizer link gebuig

Dankie Mud Dog. Dis presies wat ek toe gedoen het. Die ball joints is nog splinter nuut. Die bakkie het maar 130k km op. Ek het sondag 'n redelik klip getref gelukkig teen lae spoed. Dink dis waar dit gebeur het
by Rigger
Tue Jan 24, 2017 10:13 am
Forum: The Workshop
Topic: 3.0 D4D stabilizer link gebuig
Replies: 4
Views: 292

Re: 3.0 D4D stabilizer link gebuig

Alternatief is om dit in 'n vice te sit en reguit te druk. Ek sien met die wiele aan en in die lug, trek die linkerwiel defintief in
by Rigger
Tue Jan 24, 2017 10:01 am
Forum: The Workshop
Topic: 3.0 D4D stabilizer link gebuig
Replies: 4
Views: 292

3.0 D4D stabilizer link gebuig

Goeie dag manne.

Ek is besig om my Hilux te diens en sien die linkerkanste stabilzer link is gebuig. Dit is nie erg gebuig nie maar wil graag raad he of ek dadelik moet vervang en of dit nie doodsake is nie. Prys by Toyota is so R1500 :shock2:
by Rigger
Mon Jan 16, 2017 6:36 am
Forum: Vehicles For Sale
Topic: Sold - Hilux 3.0 d4d Single Cab 4x2 low kilo`s
Replies: 4
Views: 874

Re: Hilux 3.0 d4d Single Cab 4x2 low kilo`s

Looks in good condition but that i hope its old photos because that licence is a bit behind
by Rigger
Fri Jan 13, 2017 9:39 am
Forum: The Workshop
Topic: Convertion from 22R to Diesel on a 1995 Hylux
Replies: 7
Views: 433

Re: Convertion from 22R to Diesel on a 1995 Hylux

That is correct, its the 2.5 Tdi. There is also a normal aspirated WL but try to get the turbo version
by Rigger
Thu Jan 12, 2017 7:56 pm
Forum: The Workshop
Topic: Convertion from 22R to Diesel on a 1995 Hylux
Replies: 7
Views: 433

Re: Convertion from 22R to Diesel on a 1995 Hylux

Straight fit would be a 2L or 3L but i am not sure if the bell housing and other parts like exhaust manifould is a straight fit. Otherwise I see alot of guys install the Ford WL engine but that is a conversion and you asked for straight fit so just mentioned it
by Rigger
Sun Jan 08, 2017 7:16 pm
Forum: Open Discussion
Topic: Dakar 2017
Replies: 37
Views: 2261

Re: Dakar 2017

Nani Roma is 4de, 5:35 agter Peterhansel wat 1ste is so hy moet nou maar die Hilux podium toe vat
by Rigger
Thu Jan 05, 2017 8:58 am
Forum: Open Discussion
Topic: Dakar 2017
Replies: 37
Views: 2261

Re: Dakar 2017

Dit is sleg laat Nasser uit is. Hy was 'n goeie man om op Giniel se span te hê. Nou moet Giniel maar alleen die Hilux op die podium sit
by Rigger
Thu Jan 05, 2017 8:55 am
Forum: Open Discussion
Topic: Special stages on the Dakar route
Replies: 2
Views: 274

Re: Special stages on the Dakar route

Dit is die gedeelte van die roete wat hulle teen tyd ry
by Rigger
Sat Dec 31, 2016 2:11 pm
Forum: Open Discussion
Topic: Is ek van looitjie getik?????
Replies: 9
Views: 693

Re: Is ek van looitjie getik?????

Ja stem saam met jou. Spandeer op goed wat geld terug bring
by Rigger
Fri Dec 30, 2016 1:31 pm
Forum: Open Discussion
Topic: Is ek van looitjie getik?????
Replies: 9
Views: 693

Re: Is ek van looitjie getik?????

Voor ek daai tipe geld spandeer op 'n Dodge of Ford koop ek n V8 D/C Cruiser of as jou beursie jou regtig brand en jy soek baie spasie hoekom nie 'n 200 VX nie? Toyota bly mos maar koning
by Rigger
Thu Dec 29, 2016 5:04 am
Forum: Open Discussion
Topic: Is ek van looitjie getik?????
Replies: 9
Views: 693

Re: Is ek van looitjie getik?????

My pa het twee gehad, eers die DC en toe die S/C. Parte is ongelooflik duur. Voor wiel bearing bv R13 000. Op 330000km toe gaan die agter diff en ratkas. Kry toe kwotasies om reg te maak. R198 000 was die goedkoopste
by Rigger
Wed Dec 28, 2016 7:24 pm
Forum: Out in Nature
Topic: blue lizard
Replies: 1
Views: 861

Re: blue lizard

Blue headed agama lizard, Afrikaans: Bloukop koggelmander
by Rigger
Tue Dec 27, 2016 5:44 pm
Forum: General Hilux Discussions
Topic: Hilux poem
Replies: 11
Views: 701

Re: Hilux poem

Love it!!!!!
by Rigger
Tue Dec 27, 2016 11:38 am
Forum: General Hilux Discussions
Topic: Replacing my Tyres
Replies: 9
Views: 979

Re: Replacing my Tyres

I recently asked the same question about tires. Although I replaced mine with BFG KO2, many forum members suggested General Grabbers. The Yokohama Geolander is also not a bad tire IMHO
by Rigger
Sun Dec 25, 2016 10:18 pm
Forum: Vehicles For Sale
Topic: SOLD - SFA 1994 DC Hilux Lexus v8 for sale R115000
Replies: 24
Views: 2310

Re: SOLD - SFA 1994 DC Hilux Lexus v8 for sale R115000

So you want a vehicle with very low gears, big wheels, great off road and not very fast. Why not buy a tractor? :D:
by Rigger
Thu Dec 15, 2016 6:10 pm
Forum: The Workshop
Topic: Welding thin plate ...
Replies: 16
Views: 746

Re: Welding thin plate ...

For an inexperience welder i would not concider it. Arc welding is very difficult on thin plate. Best would be to tack, cool down, tack, cool down etc. Don't try to weld a complete run as the heat will get too much. Most probably going to end up with lots of holes burnt through if you try to weld a ...
by Rigger
Mon Dec 05, 2016 4:57 am
Forum: The Workshop
Topic: 4.0 v6 toyota landcruiser prado slight missfire
Replies: 3
Views: 286

Re: 4.0 v6 toyota landcruiser prado slight missfire

Wat se die rekenaar, gooi dit geen fault codes? Al die vacuum hoses reg terug gesit? Foutiewe TPS?

Go to advanced search