Hilux p0335 crank sensor problem

Having problems with your vehicle? Or need advice on repairing or servicing your Hilux? This is the place to ask for help
Post Reply
jdreyer77
Newbie
Posts: 9
Joined: Sun Mar 17, 2013 7:57 pm
Town: Pretoria
Vehicle: Hilux
Real Name: Johan

Sat Jul 07, 2018 4:18 pm

I need some help please.

I had a dieseltorque chip for 2 years in n Hilux d4d with no problem. Bakkie was serviced recently 230 000km and about 2 week later the engine went to limp mode whilst driving. Switched off and on and continued driving. The problem then came back every 3rd or 4th day. Decided to remove the chip and do software rather. Whilst driving without the chip the problem was worse. Upgraded the software and even worse. The bakkie is no dying when idling. We used a diagnostics machine and the error P0335 crank sensor circuit at.

I have replaced the following (swopping parts between 2 identical bakkies)

Crank sensor
Fuel sensor
Starter
New timing belt and tensioner
Check crank sensor for lose wires
Battery
Checked regulator ring

The promblem is still there. The problem is now so bad that the motor is not going to limp mode but engine stalls and you have to completely switch off, removr key and start again. The problem also occurs at any rpm, from idling to 3000 rpm.

Any ideas?

Mars
LR4WD, Lockers, Crawler Gears
LR4WD, Lockers, Crawler Gears
Posts: 1228
Joined: Mon May 07, 2012 12:33 pm
Town: Pretoria
Vehicle: Toyota Hilux Dakar 2.8 GD-6 DC 4X4
Real Name: Marnus
Location: Pretoria Oos
Contact:

Mon Jul 09, 2018 8:07 am

Maak seker dat jou diesel toevoer ook reg is Johan. Gewoonlik sal die fout op die rekenaar vir jou 'n baie goeie indikasie gee van die probleem maar soms is dit iets anders. Het hulle die diesel filter vervang toe hulle die bakkie gediens het? Ek sou kyk of die diesel filter skoon is en veral dat die ring bo-op die filter eenheid behoorlik vasgedraai is en seel.

jdreyer77
Newbie
Posts: 9
Joined: Sun Mar 17, 2013 7:57 pm
Town: Pretoria
Vehicle: Hilux
Real Name: Johan

Tue Jul 10, 2018 7:15 am

Ons het alles al vervang:

Crank sensor
Cam sensor
MAF sensor skoon gemaak
Nuwe Cam belt en tensioner
Fuel pump geruil
Nuwe diesel filter
Harnas oopgemaak en drade getoets

Hy doen dit minder na die fuel pump geruil is, maar probleem nog nie weg nie

Post Reply

Return to “The Workshop”

  • Information
  • Who is online

    Users browsing this forum: tecsol