Today I was told my 3.0 D4D's injectors are failing.
2007 model with 160 000 on the clock.
I have been told it's rather premature and that I may have a leg to stand on with Toyota ZA
I have been quoted R30k for the job of replacing etc.
Any input is highly appreciated
Sent from my JAZZ using Tapatalk
Injectors
- Jaws
- LR 4WD Full Lockers
- Posts: 536
- Joined: Fri Dec 14, 2007 11:41 am
- Town: Sharonlea
- Vehicle: 2009 D4D 4x4
- Real Name: Herman
Re: Injectors
I highly doubt TSA will stand in, car is almost 10 years old.
Sent from my iPhone using Tapatalk
Sent from my iPhone using Tapatalk
- ChrisF
- Top Web Wheeler
- Posts: 8188
- Joined: Thu Sep 17, 2009 2:56 pm
- Town: inniedorp
- Vehicle: Toy
- Real Name: Chris
Re: Injectors
warrantee expired at 5 years and/or 90 000km, unless you took out an extended warantee.
sadly this IS the weakpoint of the D-4D.
sadly this IS the weakpoint of the D-4D.
-
- Monster Truck
- Posts: 7249
- Joined: Fri Oct 12, 2007 2:38 pm
- Town: Cape Town
- Vehicle: Honda Jazz
- Real Name: Bretton
- Location: Brackenfell
Re: Injectors
Personally I wouldn't get Toyota to do the job. There are many excellent diesel shops around and the injectors themselves cost around R14k for a OEM set. So Toyota would be charging you some R15k for a simple replacement job. That's a rip-off.
Ask the guys on the forum to suggest a reliable diesel shop in your area!
In fact I see you're in Table View... contact Allan Venter(Mr Hilux Cape Town) for advise on the best route to go.
Ask the guys on the forum to suggest a reliable diesel shop in your area!
In fact I see you're in Table View... contact Allan Venter(Mr Hilux Cape Town) for advise on the best route to go.
-
- Low Range 4WD
- Posts: 171
- Joined: Sun Jan 24, 2016 1:13 am
- Town: Griffith
- Vehicle: 07 Hilux SR5
- Real Name: Luke
Re: Injectors
160k isnt premature! Some do get way more but most dont last that long especially being an 07. If they r still the original ones then they wont be the updated version. I've seen plenty fail with less than a third of those ks! Make sure you get the updated injectors and seat washers too. Also tell them to make not, if any of the seat washers have been leaking then you'll need to check your oil pick-up screen in the sump. Has been a massive problem here with toyota doing a recall on a stack of utes. Once them seats start leaking it doesn't take long to rite off the block!!
Sent from my SM-N920I using Tapatalk
Sent from my SM-N920I using Tapatalk
-
- LR4WD, Lockers, Crawler Gears
- Posts: 1484
- Joined: Mon May 07, 2012 12:33 pm
- Town: Pretoria
- Vehicle: Toyota Hilux Dakar 2.8 GD-6 DC 4X4
- Real Name: Marnus
- Location: Pretoria Oos
- Contact:
Re: Injectors
If you do a search on injectors you will see a couple of posts discussing the issue. I am not aware of a single instance of seats leaking in SA. I did all the research and ultimately it turns out that replacing the injectors with new ones is the best option as the reconditioning of the injectors (whilst done regularly) sometimes gives issues.
It is not the hardest of jobs to do but you need the Toyota scanner or similar software such as Techstream to recode the new injectors to the ECU. It is also important to make sure the seats are clean (i.e. that there are no carbon deposits on the seats - which is achieved by very lightly scraping the seats with a reamer coated with grease) and to replace the injector seat washers. They will supply new seat washers with the injectors. It is also highly recommended to replace the 5 injector leakage return pipe combination washers (it is two aluminium washers connected with a tab that sit on either side of the banjo connectors on top of each injector and on the cylinder head) as you will not know if the old ones are leaking until you find your oil being thinned by diesel. It is possible to check for leakage on the rail with specialised equipment.
I agree with taking it to a diesel shop. Make sure that the diesel filter housing is clean and also that you replace the diesel filter when changing the injectors.
It is not the hardest of jobs to do but you need the Toyota scanner or similar software such as Techstream to recode the new injectors to the ECU. It is also important to make sure the seats are clean (i.e. that there are no carbon deposits on the seats - which is achieved by very lightly scraping the seats with a reamer coated with grease) and to replace the injector seat washers. They will supply new seat washers with the injectors. It is also highly recommended to replace the 5 injector leakage return pipe combination washers (it is two aluminium washers connected with a tab that sit on either side of the banjo connectors on top of each injector and on the cylinder head) as you will not know if the old ones are leaking until you find your oil being thinned by diesel. It is possible to check for leakage on the rail with specialised equipment.
I agree with taking it to a diesel shop. Make sure that the diesel filter housing is clean and also that you replace the diesel filter when changing the injectors.
-
- High Range 4WD
- Posts: 45
- Joined: Thu Aug 05, 2010 6:22 pm
- Town: Table View
- Vehicle: Hilux D4D 4x2
- Real Name: Jody
- Location: Table View
Re: Injectors
Thanks everyone
Sent from my JAZZ using Tapatalk
Sent from my JAZZ using Tapatalk
- Jaws
- LR 4WD Full Lockers
- Posts: 536
- Joined: Fri Dec 14, 2007 11:41 am
- Town: Sharonlea
- Vehicle: 2009 D4D 4x4
- Real Name: Herman
Re: Injectors
Seems like injector failing is more prominent in pre 09 Hiluxes
Seen a few 09+ models with high milage on original injectors .
Mine is almost on 180k with original injectors and according to techstream all four perfectly in spec .
Sent from my iPhone using Tapatalk
Seen a few 09+ models with high milage on original injectors .
Mine is almost on 180k with original injectors and according to techstream all four perfectly in spec .
Sent from my iPhone using Tapatalk