Overheating Hilux 2700i (2001 model)
-
- High Range 4WD
- Posts: 75
- Joined: Wed Nov 11, 2009 3:05 pm
- Town: Cape Town
- Vehicle: '01 Hilux 2700i D/C 4x4
- Real Name: Craig
Overheating Hilux 2700i (2001 model)
Hi Guys, I need some advice...
My Hilux is overheating when standing in traffic. Temp is quite normal while driving but if I stand still in traffic it starts to heat up and if I don't get moving it gets very close to the red. When I drive off it immediately drops back to normal operating temp. I have checked the visco fan and it is running, how effectively I don't know.
Is this something I should tackle on my own or should I involve a pro?
Thanks in advance!
My Hilux is overheating when standing in traffic. Temp is quite normal while driving but if I stand still in traffic it starts to heat up and if I don't get moving it gets very close to the red. When I drive off it immediately drops back to normal operating temp. I have checked the visco fan and it is running, how effectively I don't know.
Is this something I should tackle on my own or should I involve a pro?
Thanks in advance!
- Baasvark
- LR4WD, Lockers, Crawler Gears
- Posts: 1376
- Joined: Mon Aug 01, 2011 7:45 pm
- Town: Virginia
- Vehicle: '97 D/C with all the trimmings & 2011 Troopy
- Real Name: Shane
Re: Overheating Hilux 2700i (2001 model)
I am assuming the viscus has never been replaced? If not, that's where I would start.
We have just replaced one on a 2009 BT50, 120k km....
We also found that the radiator was very dirty on the outside between the radiator and aircon cooler.[IMG]//uploads.tapatalk-cdn.com/201809 ... 887f79.jpg[/IMG]
Sent from my SM-A720F using Tapatalk
We have just replaced one on a 2009 BT50, 120k km....
We also found that the radiator was very dirty on the outside between the radiator and aircon cooler.[IMG]//uploads.tapatalk-cdn.com/201809 ... 887f79.jpg[/IMG]
Sent from my SM-A720F using Tapatalk
Aint it ironic that "Common Sense" aint so common after all...
-
- LR4WD, Lockers, Crawler Gears
- Posts: 1484
- Joined: Mon May 07, 2012 12:33 pm
- Town: Pretoria
- Vehicle: Toyota Hilux Dakar 2.8 GD-6 DC 4X4
- Real Name: Marnus
- Location: Pretoria Oos
- Contact:
Re: Overheating Hilux 2700i (2001 model)
Hi Craig.
The bakkie is already 17 years old. Over time all the components contributing to keeping the engine cool deteriorate gradually and it is usually the collective effect that leads to what you are currently experiencing. Without being too lengthy here is what I propose you do. It will entail a full cooling system overhaul in a sense
1. Do an engine/radiator flush with one of the reputable products such as Wynns. You are going to be replacing the coolant anyway.
2. Replace the Thermostat. It is most certainly not up to spec anymore due the the many times it has opened and closed. This means it is probably not opening properly slightly hampering the flow of coolant.
2. Remove and have the radiator properly cleaned (descaled) inside as well as outside and checked for leaks.
3. Replace the water pump. (depending on how long ago it has been replaced) The impeller vanes could have deteriorated due to rust (if anti-freeze levels were not adequately maintained) and other wear such as cavitation. If you fit a new pump you eliminate one of the variables.
4. Check all the rubber hoses for damage due to perishing and replace any suspect hoses. Thoroughly clean all the fittings before you re-fit the hoses.
5. Replace the coolant with any of the reputable brand products. The Toyota product is good but expensive. You can also use one of the VW G12 replacement products sold by Goldwagen
It may sound like a lot but heat is the worst enemy of any engine. Do the above and I can guarantee you that the issue will be resolved.
The bakkie is already 17 years old. Over time all the components contributing to keeping the engine cool deteriorate gradually and it is usually the collective effect that leads to what you are currently experiencing. Without being too lengthy here is what I propose you do. It will entail a full cooling system overhaul in a sense
1. Do an engine/radiator flush with one of the reputable products such as Wynns. You are going to be replacing the coolant anyway.
2. Replace the Thermostat. It is most certainly not up to spec anymore due the the many times it has opened and closed. This means it is probably not opening properly slightly hampering the flow of coolant.
2. Remove and have the radiator properly cleaned (descaled) inside as well as outside and checked for leaks.
3. Replace the water pump. (depending on how long ago it has been replaced) The impeller vanes could have deteriorated due to rust (if anti-freeze levels were not adequately maintained) and other wear such as cavitation. If you fit a new pump you eliminate one of the variables.
4. Check all the rubber hoses for damage due to perishing and replace any suspect hoses. Thoroughly clean all the fittings before you re-fit the hoses.
5. Replace the coolant with any of the reputable brand products. The Toyota product is good but expensive. You can also use one of the VW G12 replacement products sold by Goldwagen
It may sound like a lot but heat is the worst enemy of any engine. Do the above and I can guarantee you that the issue will be resolved.
-
- High Range 4WD
- Posts: 75
- Joined: Wed Nov 11, 2009 3:05 pm
- Town: Cape Town
- Vehicle: '01 Hilux 2700i D/C 4x4
- Real Name: Craig
Re: Overheating Hilux 2700i (2001 model)
Thanks for the advice guys. A busy saturday for me.....
- Mud Dog
- Moderator
- Posts: 29857
- Joined: Tue Apr 29, 2008 2:18 am
- Town: East London
- Vehicle: '90 SFA Hilux DC 4X4, Full OME, 110mm lift. Brospeed branch, 50mm ss freeflow exhaust. 30 x 9.5 Discoverer S/T's on Viper mags. L/R tank. (AWOL) '98 LTD 2.4 SFA, dual battery system. Dobinson suspension, LR tanks, 31" BF mud's.
- Real Name: Andy
- Club VHF Licence: HC103
Re: Overheating Hilux 2700i (2001 model)
Agree with what Marnus is saying, it could be one or a number of causes. The fact that it cools down when driving suggests inadequate airflow to be the, or one of the factors. I would first look at the visco fan and check the cowl around the radiator and fan. Yes by all means do the radiator flush, inexpensive exercise and can only do good, but also check the condition of the radiator fins ... if they are corroding away or even clogged with insects and debris the radiator cannot do it's job properly. Replacement of the thermostat is also a good idea, easy to do and also not expensive.
Many visco fans can be refurbished by replacing the silicone oil in the hub (I think Toyota actually carry it in their spares dept.).
If all that fails, I would then replace the water pump last ... most expensive and time consuming of all the options. IMO the pumps are the least likely culprits - yes the impeller vanes can corrode / erode if there has been a long extended period without anti-freeze but generally they last pretty well and replacement is usually because of a leaking shaft seal.
Good luck.
Many visco fans can be refurbished by replacing the silicone oil in the hub (I think Toyota actually carry it in their spares dept.).
If all that fails, I would then replace the water pump last ... most expensive and time consuming of all the options. IMO the pumps are the least likely culprits - yes the impeller vanes can corrode / erode if there has been a long extended period without anti-freeze but generally they last pretty well and replacement is usually because of a leaking shaft seal.
Good luck.
When your road comes to an end ...... you need a HILUX!.
Life is like a jar of Jalapeño peppers ... what you do today, might burn your ass tomorrow.
Don't take life too seriously ..... no-one gets out alive.
It's not about waiting for storms to pass. It's about learning to dance in the rain.
And be yourself ..... everyone else is taken!
Life is like a jar of Jalapeño peppers ... what you do today, might burn your ass tomorrow.
Don't take life too seriously ..... no-one gets out alive.
It's not about waiting for storms to pass. It's about learning to dance in the rain.
And be yourself ..... everyone else is taken!
-
- High Range 4WD
- Posts: 75
- Joined: Wed Nov 11, 2009 3:05 pm
- Town: Cape Town
- Vehicle: '01 Hilux 2700i D/C 4x4
- Real Name: Craig
Re: Overheating Hilux 2700i (2001 model)
Hi Mud Dog, I have unfortunately had a period of about 5 months without anti-freeze.....procrastination is the only reason. I'm hoping the damage is not too bad!Mud Dog wrote: ↑Thu Sep 06, 2018 9:30 pm Agree with what Marnus is saying, it could be one or a number of causes. The fact that it cools down when driving suggests inadequate airflow to be the, or one of the factors. I would first look at the visco fan and check the cowl around the radiator and fan. Yes by all means do the radiator flush, inexpensive exercise and can only do good, but also check the condition of the radiator fins ... if they are corroding away or even clogged with insects and debris the radiator cannot do it's job properly. Replacement of the thermostat is also a good idea, easy to do and also not expensive.
Many visco fans can be refurbished by replacing the silicone oil in the hub (I think Toyota actually carry it in their spares dept.).
If all that fails, I would then replace the water pump last ... most expensive and time consuming of all the options. IMO the pumps are the least likely culprits - yes the impeller vanes can corrode / erode if there has been a long extended period without anti-freeze but generally they last pretty well and replacement is usually because of a leaking shaft seal.
Good luck.
- Mud Dog
- Moderator
- Posts: 29857
- Joined: Tue Apr 29, 2008 2:18 am
- Town: East London
- Vehicle: '90 SFA Hilux DC 4X4, Full OME, 110mm lift. Brospeed branch, 50mm ss freeflow exhaust. 30 x 9.5 Discoverer S/T's on Viper mags. L/R tank. (AWOL) '98 LTD 2.4 SFA, dual battery system. Dobinson suspension, LR tanks, 31" BF mud's.
- Real Name: Andy
- Club VHF Licence: HC103
Re: Overheating Hilux 2700i (2001 model)
Well the cooling system needs a functional radiator, adequate airflow to cool it and adequate coolant reticulation / flow to take the heat away from the motor.
It also to a lesser degree needs a pressurised system because the boiling point of the coolant is raised if under pressure - anti-freeze also helps raise it further. If you're not loosing coolant then you should be OK in this area.
Airflow is affected by the efficiency of the fan (the cowl plays an important part here) and if there are any obstructions to airflow like spots or stuff mounted in front of the radiator grille and of course debris blocking the radiator fins.
Reticulation is affected by the efficiency of the pump or any obstructions like a partially open thermostat, blocked water galleries in the motor (head) or a chocked radiator.
Given the age of the vehicle and having run without anti-freeze, the possibility of the pump being the or one of the culprits becomes greater. I hope it's not the cause but I'm not holding thumbs on that either now.
It also to a lesser degree needs a pressurised system because the boiling point of the coolant is raised if under pressure - anti-freeze also helps raise it further. If you're not loosing coolant then you should be OK in this area.
Airflow is affected by the efficiency of the fan (the cowl plays an important part here) and if there are any obstructions to airflow like spots or stuff mounted in front of the radiator grille and of course debris blocking the radiator fins.
Reticulation is affected by the efficiency of the pump or any obstructions like a partially open thermostat, blocked water galleries in the motor (head) or a chocked radiator.
Given the age of the vehicle and having run without anti-freeze, the possibility of the pump being the or one of the culprits becomes greater. I hope it's not the cause but I'm not holding thumbs on that either now.
When your road comes to an end ...... you need a HILUX!.
Life is like a jar of Jalapeño peppers ... what you do today, might burn your ass tomorrow.
Don't take life too seriously ..... no-one gets out alive.
It's not about waiting for storms to pass. It's about learning to dance in the rain.
And be yourself ..... everyone else is taken!
Life is like a jar of Jalapeño peppers ... what you do today, might burn your ass tomorrow.
Don't take life too seriously ..... no-one gets out alive.
It's not about waiting for storms to pass. It's about learning to dance in the rain.
And be yourself ..... everyone else is taken!
-
- High Range 4WD
- Posts: 75
- Joined: Wed Nov 11, 2009 3:05 pm
- Town: Cape Town
- Vehicle: '01 Hilux 2700i D/C 4x4
- Real Name: Craig
Re: Overheating Hilux 2700i (2001 model)
I bled the system after using radiator flush. Water was not as bad as I thought it would be. I replaced the thermostat, it looked a bit worse for wear! System was reloaded with water & antifreeze mixture and seems to be working. Big test is tomorrows traffic. I tried idling it to make it overheat but it stayed constant. Hold thumbs!
-
- High Range 4WD
- Posts: 75
- Joined: Wed Nov 11, 2009 3:05 pm
- Town: Cape Town
- Vehicle: '01 Hilux 2700i D/C 4x4
- Real Name: Craig
Re: Overheating Hilux 2700i (2001 model)
Drive to work was uneventful but the traffic was very light. The few times I parked at an intersection the temp needle didn't move. I'm hoping the problem is now in the past. I'll find out for sure this afternoon as my afternoon commute is a lot heavier than the morning one!
One thing I failed to mention in the previous post, when I added the radiator flush the water level in the radiator was quite low. I needed to add at least 1,5l of water as well as the 450ml of radiator flush to top up the system. The resevoir bottle was full though. In fact is was about 50% over filled.
I did blow out the siphen pipe in case there was a blockage in there. I'll be checking the water levels daily now to make sure the engine isn't using water. As a side note...I've not previously had any water or oil usage issues.
One thing I failed to mention in the previous post, when I added the radiator flush the water level in the radiator was quite low. I needed to add at least 1,5l of water as well as the 450ml of radiator flush to top up the system. The resevoir bottle was full though. In fact is was about 50% over filled.
I did blow out the siphen pipe in case there was a blockage in there. I'll be checking the water levels daily now to make sure the engine isn't using water. As a side note...I've not previously had any water or oil usage issues.
- Mud Dog
- Moderator
- Posts: 29857
- Joined: Tue Apr 29, 2008 2:18 am
- Town: East London
- Vehicle: '90 SFA Hilux DC 4X4, Full OME, 110mm lift. Brospeed branch, 50mm ss freeflow exhaust. 30 x 9.5 Discoverer S/T's on Viper mags. L/R tank. (AWOL) '98 LTD 2.4 SFA, dual battery system. Dobinson suspension, LR tanks, 31" BF mud's.
- Real Name: Andy
- Club VHF Licence: HC103
Re: Overheating Hilux 2700i (2001 model)
The overheating at stops could have pushed that water out. 1.5 lit is a lot, even half a litre short will make a difference.
What concerns me is that it wasn't sucked back into the radiator from the reservoir ... could be that the radiator cap is also faulty, so I would replace it anyway - just to be sure.
Check the coolant levels (radiator and reservoir) in the mornings when the motor is properly cold.
Good luck, hope your problem is solved.
What concerns me is that it wasn't sucked back into the radiator from the reservoir ... could be that the radiator cap is also faulty, so I would replace it anyway - just to be sure.
Check the coolant levels (radiator and reservoir) in the mornings when the motor is properly cold.
Good luck, hope your problem is solved.
When your road comes to an end ...... you need a HILUX!.
Life is like a jar of Jalapeño peppers ... what you do today, might burn your ass tomorrow.
Don't take life too seriously ..... no-one gets out alive.
It's not about waiting for storms to pass. It's about learning to dance in the rain.
And be yourself ..... everyone else is taken!
Life is like a jar of Jalapeño peppers ... what you do today, might burn your ass tomorrow.
Don't take life too seriously ..... no-one gets out alive.
It's not about waiting for storms to pass. It's about learning to dance in the rain.
And be yourself ..... everyone else is taken!
-
- LR4WD, Lockers, Crawler Gears
- Posts: 1484
- Joined: Mon May 07, 2012 12:33 pm
- Town: Pretoria
- Vehicle: Toyota Hilux Dakar 2.8 GD-6 DC 4X4
- Real Name: Marnus
- Location: Pretoria Oos
- Contact:
Re: Overheating Hilux 2700i (2001 model)
Yes that is good advice to replace the radiator cap. I forgot to mention that and make sure that the surfaces where the radiator cap mates on the radiator are clean and smooth to ensure a good seal there.
- Baasvark
- LR4WD, Lockers, Crawler Gears
- Posts: 1376
- Joined: Mon Aug 01, 2011 7:45 pm
- Town: Virginia
- Vehicle: '97 D/C with all the trimmings & 2011 Troopy
- Real Name: Shane
Re: Overheating Hilux 2700i (2001 model)
Make sure you replace with the correct rating cap...
I know this sounds silly, but I was losing coolant on my 1HZ. Replaced the cap, nothing changed.
Then I saw online that my vehicle uses a 0.9bar cap and not the 1.1 that was on.....
Changed again and problem solved!
Not sure why though...
Sent from my SM-A720F using Tapatalk
I know this sounds silly, but I was losing coolant on my 1HZ. Replaced the cap, nothing changed.
Then I saw online that my vehicle uses a 0.9bar cap and not the 1.1 that was on.....
Changed again and problem solved!
Not sure why though...
Sent from my SM-A720F using Tapatalk
Aint it ironic that "Common Sense" aint so common after all...
-
- LR4WD, Lockers, Crawler Gears
- Posts: 1484
- Joined: Mon May 07, 2012 12:33 pm
- Town: Pretoria
- Vehicle: Toyota Hilux Dakar 2.8 GD-6 DC 4X4
- Real Name: Marnus
- Location: Pretoria Oos
- Contact:
Re: Overheating Hilux 2700i (2001 model)
The system is designed to work as a specific maximum pressure. If you get a cap that is below that rating it is going to release pressure with the accompanying coolant.
- Baasvark
- LR4WD, Lockers, Crawler Gears
- Posts: 1376
- Joined: Mon Aug 01, 2011 7:45 pm
- Town: Virginia
- Vehicle: '97 D/C with all the trimmings & 2011 Troopy
- Real Name: Shane
Re: Overheating Hilux 2700i (2001 model)
Mine worked the other way around...cap rating was lower than the cap it had.Mars wrote:The system is designed to work as a specific maximum pressure. If you get a cap that is below that rating it is going to release pressure with the accompanying coolant.
Sent from my SM-A720F using Tapatalk
Aint it ironic that "Common Sense" aint so common after all...
-
- LR4WD, Lockers, Crawler Gears
- Posts: 1484
- Joined: Mon May 07, 2012 12:33 pm
- Town: Pretoria
- Vehicle: Toyota Hilux Dakar 2.8 GD-6 DC 4X4
- Real Name: Marnus
- Location: Pretoria Oos
- Contact:
Re: Overheating Hilux 2700i (2001 model)
Sorry I did not read your post properly. Yes that is strange.
- Mud Dog
- Moderator
- Posts: 29857
- Joined: Tue Apr 29, 2008 2:18 am
- Town: East London
- Vehicle: '90 SFA Hilux DC 4X4, Full OME, 110mm lift. Brospeed branch, 50mm ss freeflow exhaust. 30 x 9.5 Discoverer S/T's on Viper mags. L/R tank. (AWOL) '98 LTD 2.4 SFA, dual battery system. Dobinson suspension, LR tanks, 31" BF mud's.
- Real Name: Andy
- Club VHF Licence: HC103
Re: Overheating Hilux 2700i (2001 model)
Shane, the probable reason for loosing coolant with the higher rated cap is that the resulting additional pressure in the system could have pushed coolant past a hose clamp or even the pump seal. If that was the case then you would have lost coolant.
When your road comes to an end ...... you need a HILUX!.
Life is like a jar of Jalapeño peppers ... what you do today, might burn your ass tomorrow.
Don't take life too seriously ..... no-one gets out alive.
It's not about waiting for storms to pass. It's about learning to dance in the rain.
And be yourself ..... everyone else is taken!
Life is like a jar of Jalapeño peppers ... what you do today, might burn your ass tomorrow.
Don't take life too seriously ..... no-one gets out alive.
It's not about waiting for storms to pass. It's about learning to dance in the rain.
And be yourself ..... everyone else is taken!
-
- High Range 4WD
- Posts: 75
- Joined: Wed Nov 11, 2009 3:05 pm
- Town: Cape Town
- Vehicle: '01 Hilux 2700i D/C 4x4
- Real Name: Craig
Re: Overheating Hilux 2700i (2001 model)
I'm going to check the levels now during our lunch break.Mud Dog wrote: ↑Mon Sep 10, 2018 8:28 am The overheating at stops could have pushed that water out. 1.5 lit is a lot, even half a litre short will make a difference.
What concerns me is that it wasn't sucked back into the radiator from the reservoir ... could be that the radiator cap is also faulty, so I would replace it anyway - just to be sure.
Check the coolant levels (radiator and reservoir) in the mornings when the motor is properly cold.
Good luck, hope your problem is solved.
Good point on the radiator cap. I'll check the condition of that too and call around for a replacement! Would a normal spares shop stock it?
-
- High Range 4WD
- Posts: 75
- Joined: Wed Nov 11, 2009 3:05 pm
- Town: Cape Town
- Vehicle: '01 Hilux 2700i D/C 4x4
- Real Name: Craig
Re: Overheating Hilux 2700i (2001 model)
Radiator level is low again.....it is a 1.1 bar cap. I'll calll around for a replacement!
-
- LR4WD, Lockers, Crawler Gears
- Posts: 1484
- Joined: Mon May 07, 2012 12:33 pm
- Town: Pretoria
- Vehicle: Toyota Hilux Dakar 2.8 GD-6 DC 4X4
- Real Name: Marnus
- Location: Pretoria Oos
- Contact:
Re: Overheating Hilux 2700i (2001 model)
Don't stress too quickly. The level will drop after you have done a coolant replacement even if you bled the system. Top it up, drive it home and check again tomorrow morning. The spares places should stock them. Was the higher pressure cap on there all the time before?
-
- High Range 4WD
- Posts: 64
- Joined: Tue Jun 23, 2015 10:06 am
- Town: durban
- Vehicle: D4D hilux DC $X$
- Real Name: Lorenzo
Re: Overheating Hilux 2700i (2001 model)
the level may drop to a air pocket that may have formed when refilling it, as commented above, top it up and monitor it
- Baasvark
- LR4WD, Lockers, Crawler Gears
- Posts: 1376
- Joined: Mon Aug 01, 2011 7:45 pm
- Town: Virginia
- Vehicle: '97 D/C with all the trimmings & 2011 Troopy
- Real Name: Shane
Re: Overheating Hilux 2700i (2001 model)
Not saying yours is incorrect. Just confirm that 1.1 is the correct rating....Sylvester wrote:Radiator level is low again.....it is a 1.1 bar cap. I'll calll around for a replacement!
Sent from my SM-A720F using Tapatalk
Aint it ironic that "Common Sense" aint so common after all...
-
- High Range 4WD
- Posts: 75
- Joined: Wed Nov 11, 2009 3:05 pm
- Town: Cape Town
- Vehicle: '01 Hilux 2700i D/C 4x4
- Real Name: Craig
Re: Overheating Hilux 2700i (2001 model)
That is a good point and exactly as you implied, the water level seems to be consistant now. I'll keep monitoring though. I am going to do another flush in a week or two as I am now unhappy with the ratio of water/antifreeze with the recent top ups it has been pure water.
-
- High Range 4WD
- Posts: 75
- Joined: Wed Nov 11, 2009 3:05 pm
- Town: Cape Town
- Vehicle: '01 Hilux 2700i D/C 4x4
- Real Name: Craig
Re: Overheating Hilux 2700i (2001 model)
It is the same radiator cap that has always been on the vehicle for the last 5 years since the radiator was replaced so I am hoping/assuming it is correct.
-
- High Range 4WD
- Posts: 75
- Joined: Wed Nov 11, 2009 3:05 pm
- Town: Cape Town
- Vehicle: '01 Hilux 2700i D/C 4x4
- Real Name: Craig
Re: Overheating Hilux 2700i (2001 model)
Thanks for all the advice guys, really great to have it "at your fingertips"!
One final question...
What is the ratio of water to Antifreeze supposed to be?
One final question...
What is the ratio of water to Antifreeze supposed to be?
- Tim86
- LR 4WD Rear Locker
- Posts: 298
- Joined: Tue Apr 12, 2016 10:33 pm
- Town: Cape Town
- Vehicle: Hilux
- Real Name: Tim
Re: Overheating Hilux 2700i (2001 model)
Depends if it says Premix on the bottle or not. Premix (such as Castrol Radicool and Toyota OE) you put in neat. Additive coolants are often 50:50 with water. Those will most likely tell you on the label.
-
- Monster Truck
- Posts: 2075
- Joined: Sat Jan 19, 2008 4:23 pm
- Town: Springs
- Vehicle: Hilux 2700i
- Real Name: Johan
- Club VHF Licence: HC262
- Location: Selection Park
Re: Overheating Hilux 2700i (2001 model)
I have the same problem just the other way around.Cools down on idle and heats up on driving.
2004 Hilux 2700i 4x4 Legend 35
Cowley branch and freeflow,long range tank,dual battery system,home made front and rear bumpers.
Cowley branch and freeflow,long range tank,dual battery system,home made front and rear bumpers.
-
- Monster Truck
- Posts: 2075
- Joined: Sat Jan 19, 2008 4:23 pm
- Town: Springs
- Vehicle: Hilux 2700i
- Real Name: Johan
- Club VHF Licence: HC262
- Location: Selection Park
Re: Overheating Hilux 2700i (2001 model)
Hi.I know its been over a year but here is some feedback from my side.I replaced radiator cap and no change.Then I flushed the cooling system and the problem was worse.I then send the radiator in for a service as I also had a leak on it and replaced the thermostat.Still not fixed.I then bought a new water pump and viscous coupling.When I took the old water pump off it looked better than the new one If bought,so I put It back .Then I changed the viscous and problem solved.Just a side note on the viscous.It may seems to work but its not always efficient.
2004 Hilux 2700i 4x4 Legend 35
Cowley branch and freeflow,long range tank,dual battery system,home made front and rear bumpers.
Cowley branch and freeflow,long range tank,dual battery system,home made front and rear bumpers.
-
- High Range 4WD
- Posts: 75
- Joined: Sun Jun 01, 2014 7:57 am
- Town: Nelspruit
- Vehicle: Hilux 2.7 D/C
- Real Name: Henk
Re: Overheating Hilux 2700i (2001 model)
Thank you for the feedback! Always learning.
Sent from my FIG-LX1 using Tapatalk
Sent from my FIG-LX1 using Tapatalk
Using Tapatalk
-
- High Range 4WD
- Posts: 75
- Joined: Sun Jun 01, 2014 7:57 am
- Town: Nelspruit
- Vehicle: Hilux 2.7 D/C
- Real Name: Henk
Re: Overheating Hilux 2700i (2001 model)
How many kms on the engine?
Sent from my FIG-LX1 using Tapatalk
Sent from my FIG-LX1 using Tapatalk
Using Tapatalk
-
- Monster Truck
- Posts: 2075
- Joined: Sat Jan 19, 2008 4:23 pm
- Town: Springs
- Vehicle: Hilux 2700i
- Real Name: Johan
- Club VHF Licence: HC262
- Location: Selection Park
Re: Overheating Hilux 2700i (2001 model)
317000 and going strong.
2004 Hilux 2700i 4x4 Legend 35
Cowley branch and freeflow,long range tank,dual battery system,home made front and rear bumpers.
Cowley branch and freeflow,long range tank,dual battery system,home made front and rear bumpers.
-
- High Range 4WD
- Posts: 75
- Joined: Sun Jun 01, 2014 7:57 am
- Town: Nelspruit
- Vehicle: Hilux 2.7 D/C
- Real Name: Henk
Re: Overheating Hilux 2700i (2001 model)
Great! My 2.7 only on 118k. 2004. No issues.legend35 wrote:317000 and going strong.
Glad you got it sorted!
Sent from my FIG-LX1 using Tapatalk
Using Tapatalk
-
- High Range 4WD
- Posts: 38
- Joined: Fri Jul 21, 2017 9:04 pm
- Town: midrand
- Vehicle: TOYOTA HILUX
- Real Name: MUDAVANHU
Re: Overheating Hilux 2700i (2001 model)
just a question,what is the right coolant for this type of bakkie and ratios to mix it
-
- High Range 4WD
- Posts: 38
- Joined: Fri Jul 21, 2017 9:04 pm
- Town: midrand
- Vehicle: TOYOTA HILUX
- Real Name: MUDAVANHU
Re: Overheating Hilux 2700i (2001 model)
mine was overheating ,replaced with toyota parts,viscous fan ,water pump and thermostat overheating problem solved.drove across Botswana at 47 degrees inside bakkie all was good
- Mud Dog
- Moderator
- Posts: 29857
- Joined: Tue Apr 29, 2008 2:18 am
- Town: East London
- Vehicle: '90 SFA Hilux DC 4X4, Full OME, 110mm lift. Brospeed branch, 50mm ss freeflow exhaust. 30 x 9.5 Discoverer S/T's on Viper mags. L/R tank. (AWOL) '98 LTD 2.4 SFA, dual battery system. Dobinson suspension, LR tanks, 31" BF mud's.
- Real Name: Andy
- Club VHF Licence: HC103
Re: Overheating Hilux 2700i (2001 model)
As mentioned before, the Toyota brand coolant is probably the best way to go. Not only that it's recommended by the manufacturer but also because it compares well against other leading 'off-the-shelf' brands IRO of price.
The brand of coolant / additive is however not that important when it comes down to the efficiency of the cooling system. Yes, it helps by raising the boiling point by comparison to pure water and it lubricates the pump seal as well as inhibits corrosion, particularly the aluminium surfaces.
The efficiency of the system (in either hot or cold ambient temperatures) depends on the effectiveness of a couple key things.
They are:
Efficiency of the radiator
Sufficient airflow through the radiator (not obstructed or choked)
An effective fan and cowl to draw the air
Effective pump
Effective thermostat
Correct radiator cap.
Your problem was that one or more of the replaced components was faulty or on it's way out, and resolved by replacement.
The brand of coolant / additive is however not that important when it comes down to the efficiency of the cooling system. Yes, it helps by raising the boiling point by comparison to pure water and it lubricates the pump seal as well as inhibits corrosion, particularly the aluminium surfaces.
The efficiency of the system (in either hot or cold ambient temperatures) depends on the effectiveness of a couple key things.
They are:
Efficiency of the radiator
Sufficient airflow through the radiator (not obstructed or choked)
An effective fan and cowl to draw the air
Effective pump
Effective thermostat
Correct radiator cap.
Your problem was that one or more of the replaced components was faulty or on it's way out, and resolved by replacement.
When your road comes to an end ...... you need a HILUX!.
Life is like a jar of Jalapeño peppers ... what you do today, might burn your ass tomorrow.
Don't take life too seriously ..... no-one gets out alive.
It's not about waiting for storms to pass. It's about learning to dance in the rain.
And be yourself ..... everyone else is taken!
Life is like a jar of Jalapeño peppers ... what you do today, might burn your ass tomorrow.
Don't take life too seriously ..... no-one gets out alive.
It's not about waiting for storms to pass. It's about learning to dance in the rain.
And be yourself ..... everyone else is taken!
-
- High Range 4WD
- Posts: 38
- Joined: Fri Jul 21, 2017 9:04 pm
- Town: midrand
- Vehicle: TOYOTA HILUX
- Real Name: MUDAVANHU
Re: Overheating Hilux 2700i (2001 model)
I thank you